CANGKANG PALA SEBAGAI MATERIAL PENGGANTI SEBAGIAN AGREGAT KASAR PADA BETON NORMAL

Budiman Budiman, Imran Imran, James WTP

Abstract


Abstract Normal concrete uses fine aggregate and coarse aggregate with concrete density 2200 kg/m3 -2400 kg/m3 with a compressive strength of about 15-40 MPa. The purpose of this study is to determine characteristics of the concrete aggregate and the compressive strength of the concrete design based on the DOE (Department of Environment) method and the SNI Standard. In this research, the use of nugmet shell was varied as follows: 0%, 0,25%, 0,50%, 0,75% and 1% of the cement weight. The results showed that the use of nutmeg shells as a normal concrete affected the specific gravity and the value compressive strength of concrete. The higher the percentage of nutmeg shells, the lower the specific gravity and compressive strength of the concrete. The average value of concrete density to nutmeg shell 2254.72 (kg/m3 ) and normal concrete 2304.32 (kg/m3 ). The compressive strength of normal concrete is 224.2 kg/cm2 and the concrete from nutmeg shell the composition of 0.25% and 0.5% obtained by 129.6 kg/cm2 and 140.0 kg/cm2 increases the use of nutmeg shell 0.75% and 1% obtained value of 117.6 kg/cm2 and 118.1 kg/cm2 decreased at the age of 28 days. The compressive strength of normal concrete 22 MPa while the maximum nutmeg shell concrete 14 MPa, so it does not meet the quality of normal concrete in general. Keywords: Aggregate Characteristics, nutmeg shell, Characteristics Compressive Strength

Full Text:

PDF

References


Antoni dan Paul Nugraha., 2007.Teknologi Beton.

Penerbit C.V Andi Offset, Yogyakarta.

Eni Febriani, 2013. Pengaruh Pemanfaatan

Pecahan Beton Sebagai Alternatif

Pengganti Agregat Kasar Sebagai

Campuran Beton K-250 kg/cm

. Jurnal

Untag Vol 1 No. 2, Universitas 17 Sgustus

Samarinda.

Budiman, 2020. The Use of Nutmeg Shell as a

Lightweight Concrete Material. Jurnal

INTEK Vol. 7 No. 2, hal 116-122,

Politeknik Negeri Ujung Pandang.

Deni Anwar, 2014. Pengaruh Penggunaan

Agregat Daur Ulang Terhadap Kuat

Tekan dan Modulus Elastisitas Beton

Berkinerja Tinggi Grade 80. E-Jurnal

Matriks Teknik Sipil Vo. 2 No. 2, Hal 43-

, Universitas Sebelas Maret.

Dobrowolski, A.J., 1998, Concrete

Construction Hand Book, The Mc. Graw

Hill Companies, Inc., New York.

Kabupaten Fakfak Dalam Angka 2021. Badan Pusat

Statistik Kabupaten Fakfak

Mulyono, T. (2005). Teknologi Beton. Yogyakarta :

Andi Offset.

Leonardus dan W. Valentino, 2014. Pengaruh slag

nikel sebagai pengganti sebagian agregat

kasar terhadap kuat tekan beton. Politeknik

Negeri Ujung Pandang.

Soelarso, dkk. 2016. Pengaruh penggunaan limbah

beton sebagai pengganti agregat kasar pada

beton normal terhadap kuat tekan dan

modulus elastisitas. Jurnal Fondasi, Vol. 5

No. 2, hal 22-29. Universitas Sultan Ageng

Tirtayasa.

SK SNI 03-2847-2002. Tata cara perhitungan

struktur beton untuk bangunan gedung,

Panitia Teknik Standarisasi Bidang

Konstruksi dan Bangunan, Bandung.

SK SNI 03-1974-1990. Kuat Tekan Beton. Badan

Standardisasi Nasional. 1990.

Tjokrodimuljo, K., 2007. Teknologi Beton, Penerbit

Nafiri, Yogyakarta.

Wahyu Dwi Cahyadi. 2012. Studi Kuat Tekan Beton

Normal Mutu Rendah Yang Mengandung

Abu Sekam Padi (RHA) dan Limbah

Adukan Beton (CSW)




DOI: http://dx.doi.org/10.33795/prokons.v15i2.331

Refbacks

  • There are currently no refbacks.


Copyright (c) 2021 Budiman Budiman, Imran Imran, James WTP

Creative Commons License
This work is licensed under a Creative Commons Attribution-NonCommercial 4.0 International License.

INDEXING : 

The following is an indexing list that includes the journal of the Prokons, published by the Civil Engineering Department, Politeknik Negeri Malang

          

   

     

 

_______________________________________________________________________________________________

Jurusan Teknik Sipil Politeknik Negeri Malang

Jalan Soekarno-Hatta No. 09, PO BOX 04 Malang 65141

Telp  0341-404424 ||  Fax  0341-404420

ISSN  Print (1978-1784) ||  Online (2714-8815)

Email  : prokons@polinema.ac.id

 

Creative Commons License
This work is licensed under a Creative Commons Attribution-NonCommercial 4.0 International License .